Auto Parts Search
2007 Ford E-150 CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Ford REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Driveline, U-Joint & CV Axles Replacement
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
BRAKE SERVICE PROCEDURES FOR 2007 Ford E-150 AUTOMOBILES
Power Brake Units -> Bendix Vacuum Brake Booster -> Adjustments -> E-Series, Expedition, Explorer, Explorer Sport & Sport/Trac, F-150, F-Super Duty, Mark LT, Mountaineer & Navigator -> Pushrod -> Ranger
Vehicle: 2007 Ford E-150 XL 4.6 V8 GAS
Pushrod
E-Series, Expedition, Explorer, Explorer Sport & Sport/Trac, F-150, F-Super Duty, Mark LT, Mountaineer & Navigator
- On Expedition, F-150, Mark LT and Navigator models, adjust brake booster to master cylinder pushrod length to .980-.995 inch, Fig. .
- On Explorer, Explorer Sport and Sport/Trac and Mountaineer models, adjust brake ...
CLICK HERE TO GET FULL ACCESS TO 2007 Ford E-150 BRAKE SERVICE PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2007 Ford E-150 AUTOMOBILES
DRIVESHAFT U-JOINT, Replace -> Assemble -> Disassemble -> Single Cardan, Flange Yoke -> Single Cardan, Slip Yoke
Vehicle: 2007 Ford E-150 XLT 5.4 V8 GAS
Single Cardan, Slip Yoke
Disassemble
Do not, under any circumstance, clamp the shaft in the jaws of a vise or similar holding fixture. Denting or localizing fracture can result, causing shaft failure during vehicle operation. Place the shaft on a suitable workbench. Do not damage the tube. If components are not marked and installed incorrectly, driveline imbalance can occur.
- Index-mark the shaft components.
- Remove and discard all four snap rings.
- Clamp bearing cup removal tool No. 205-086 or equivalent in a vise.
- If necessary, use a pair of pliers to remove a bearing cup t...
CLICK HERE TO GET FULL ACCESS TO 2007 Ford E-150 DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2007 Ford E-150 AUTOMOBILES
Starter, Replace
Vehicle: 2007 Ford E-150 Chateau 5.4 V8 GAS
- Disconnect battery ground cable.
- Raise and support vehicle.
- Remove starter motor solenoid terminal cover.A protective cap or boot is provided over battery input terminal on all vehicle lines and must be reinstalled after repair. Failure to follow this instruction may result in damage to vehicle.
- Remove starter solenoid S-terminal nut and S-terminal eyelet.
- Remove starter solenoid B-terminal nut and B-terminal eyelet.
- Remove starter...
CLICK HERE TO GET FULL ACCESS TO 2007 Ford E-150 STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2007 Ford E-150 AUTOMOBILES
Ford Motor Co. Trucks -> Low Oil Level Warning Indicator ->
Vehicle: 2007 Ford E-150 XL 4.6 V8 GAS
This system is used to indicate a low engine oil level condition. The lamp should light during engine starting. If oil level is sufficient, the lamp should go off when engine is operating. If oil level is low the...
CLICK HERE TO GET FULL ACCESS TO 2007 Ford E-150 MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2007 Ford E-150 AUTOMOBILES
Radiator, Replace
Vehicle: 2007 Ford E-150 Chateau 4.6 V8 GAS
- Drain cooling system into a suitable container.
- Remove front air deflector if required.
- Remove fan blade and lefthand thread clutch using a suitable fan clutch holding tooland fan clutch wrench tool.
- Disconnect and plug transmission f...
CLICK HERE TO GET FULL ACCESS TO 2007 Ford E-150 RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2007 Ford E-150 AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2007 Ford E-150 4.6 V8 GAS
- Rotate drive belt tensioner counterclockwise, using a 1/2 square hole in drive belt tensioner pull...
CLICK HERE TO GET FULL ACCESS TO 2007 Ford E-150 SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2007 Ford E-150 AUTOMOBILES
Component location diagrams for most 2007 Ford E-150 cars and light trucks sold in the U.S. from 1990+.
Engine Diagram for 2007 Ford E-150 Chateau 4.6 V8 GAS Components on diagram: |
Engine Diagram for 2007 Ford E-150 Chateau 5.4 V8 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Ford E-150 PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2007 Ford E-150 AUTOMOBILES
OEM drawn wiring diagrams for most 2007 Ford E-150 cars and light trucks sold in the U.S.
2007 Ford E-150 Chateau 5.4 V8 GAS Wiring Diagram Components on diagram: |
2007 Ford E-150 Chateau 5.4 V8 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Ford E-150 WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2007 Ford E-150 AUTOMOBILES
OEM TSB listings for most 2007 Ford E-150 cars and light trucks sold in the U.S. from 1985+.
Document: MALFUNCTION INDICATOR LAMP (MIL) ON WITH DTC P0456 - REVISED Vehicle: 2007 Ford E-150 XLT 4.6 V8 GAS Auto Systems: |
Document: RECALL - FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL Vehicle: 2007 Ford E-150 XLT 4.6 V8 GAS Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2007 Ford E-150 TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2007 Ford E-150 AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2007 Ford E-150 cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2007 Ford E-150 cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2007 Ford E-150 cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2007 Ford E-150 cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2007 Ford E-150 SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2007 Ford E-150 vehicle. |
Access the Complete guide! |