Auto Parts Search
2007 Ford Explorer Sport Trac CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Ford REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Component Locations
- Wiring Diagrams
- Technical Service Bulletins
- Specifications
- Brake Service
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Maintenance Lamp Reset
- Radiator & Hose Replacement
- Serpentine Belt Service
BRAKE SERVICE PROCEDURES FOR 2007 Ford Explorer Sport Trac AUTOMOBILES
Disc Brakes -> Caliper Service -> Assemble -> Cleaning & Inspection -> Disassemble -> E-150, E-250, E-350 & E-450 -> E-150, E-250, E-350 & E-550 -> E-450 -> E-550 -> E-Series -> Edge & MKX -> Escape & Mariner -> Expedition & Navigator -> Expedition, F-Super Duty, Motorhome & Navigator -> Explorer & Mountaineer -> Explorer Sport/Sport Trac -> Explorer, Explorer Sport/Sport Trac, Mountaineer & Ranger -> F-150 & Mark LT -> F-Super Duty & Motorhome -> Freestar & Monterey -> Front -> Inspection -> Installation -> Overhaul -> Ranger -> Rear -> Removal -> Replacement
Vehicle: 2007 Ford Explorer Sport Trac Limited 4.0 V6 GAS
Replacement
Edge & MKX
- Syphon and discard a portion of brake fluid from master cylinder.
- Raise and support vehicle, then remove wheel and tire assembly.
- Position frame side of C-clamp on inboard side of disc brake caliper. Do not place clamp frame over front brake hose.
- Position screw side of C-clamp on outboard brake shoe and lining, then tighten C-clamp until there is enough clearance to remove caliper.
- Remove front brake hose flow bolt, then disconnect and plug front brake hose. Discard copper washers.
- Remove two caliper slide pins.
- Slide brake shoe and lining out of front disc brake...
CLICK HERE TO GET FULL ACCESS TO 2007 Ford Explorer Sport Trac BRAKE SERVICE PROCEDURES
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2007 Ford Explorer Sport Trac AUTOMOBILES
CV AXLE SHAFT, Replace -> Front -> Rear
Vehicle: 2007 Ford Explorer Sport Trac Limited 4.6 V8 GAS
Front
- Loosen the front axle wheel hub retainer.
- With the vehicle in NEUTRAL, position on a hoist.
- Remove the front wheel and tire assembly.
- Remove rear disc brake caliper and suspend aside using mechanics wire.
- Remove front axle wheel hub retaining nut.
- Remove tie rod end nut and separate tie rod end from knuckle.
- Remove stabilizer bar link nut.
- Remove upper ball joint nut and separate upper ball joint from knuckle.
- Remove CV shaft assembly from vehicle.
- Reverse procedure to install, noting the following:
- Torque axle shaft hub nut to 184 ft. lbs.
- Torque upper ball joint nut to 51 ft....
CLICK HERE TO GET FULL ACCESS TO 2007 Ford Explorer Sport Trac DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2007 Ford Explorer Sport Trac AUTOMOBILES
Diagnosis & Testing -> Accessing Diagnostic Trouble Codes -> Clearing Diagnostic Trouble Codes -> Diagnostic Trouble Code Identification -> Intermittent & Poor Connections -> Intermittents -> Poor Connections -> Symptom Test
Vehicle: 2007 Ford Explorer Sport Trac Limited 4.0 V6 GAS
Accessing Diagnostic Trouble Codes
Connect a suitably programmed scan tool to DLC (Data Link Connector) and follow manufacturer's instructions.
Diagnostic Trouble Code Identification
Refer to Fig. for diagnostic trouble code identification.
Clearing Diagnostic Trouble Codes
Connect a suitably programmed scan tool to DLC (Data Link Connector), and follow manufacturer's instructions.
Symptom Test
Refer to Fig. for Symptom Test Chart.
Intermittent & Poor Connections
Intermittents
Most intermittents are caused by faulty electrical connections or wiring. Inspect for the following:
- Wiring ...
CLICK HERE TO GET FULL ACCESS TO 2007 Ford Explorer Sport Trac TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2007 Ford Explorer Sport Trac AUTOMOBILES
Starter, Replace
Vehicle: 2007 Ford Explorer Sport Trac XLT 4.0 V6 GAS
Always disconnect battery ground cable at the battery before disconnecting starter motor battery terminal lead. If a tool is shorted at the starter motor battery terminal, the tool can quickly heat enough to cause a skin burn. Failure to follow this instruction may result in serious personal injury.
- Disconnect battery ground cable.
- Raise and support vehicle.
- Remove starter motor solenoid terminal cover.A protective cap or boot is provided over battery input terminal on all vehicle lines and must be reinstalled after repair. Failure to follow this instruction may result in damage ...
CLICK HERE TO GET FULL ACCESS TO 2007 Ford Explorer Sport Trac STARTER & ALTERNATOR REPLACEMENT PROCEDURES
MAINTENANCE LAMP RESET PROCEDURES FOR 2007 Ford Explorer Sport Trac AUTOMOBILES
Ford Motor Co. Trucks -> Tire Pressure Monitoring System (TPMS) Warning Indicator -> 2007-09 Explorer Sport Trac -> Relearn -> Reset -> TPMS Sensor Activation -> TPMS Sensor Training
Vehicle: 2007 Ford Explorer Sport Trac Limited 4.0 V6 GAS
Reset
If the system detects low tire pressure, CHECK TIRE PRESSURE lamp will illuminate. Inflating tire(s) to recommended pressure will clear the tire message. Up to two minutes of driving above 20 mph may be required for the warning lamp to turn OFF after the tires have been filled to the recommended pressure.
Relearn
TPMS Sensor Activation
To conserve battery power, the TPMS sensors will go into a sleep mode after approximately 30 minutes of inactivity. The sensors will not transmit tire pressure information while in sleep mode. The sensors must be activated to transmi...
CLICK HERE TO GET FULL ACCESS TO 2007 Ford Explorer Sport Trac MAINTENANCE LAMP RESET PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2007 Ford Explorer Sport Trac AUTOMOBILES
Heater Hose, Replace -> Bypass -> Inlet -> Outlet
Vehicle: 2007 Ford Explorer Sport Trac XLT 4.0 V6 GAS
Inlet
- Drain cooling system into a suitable container.
- Reposition heater core inlet hose clamp at thermostat housing.
- Remove hose from thermostat housing.
- Reposition heater hose inlet clamp at heater core.
- Remove heater inlet hose from heater core.
- Remove hose from vehicle.
- Reverse procedure to install.
Outlet
- Drain cooling system into a suitable container.
- Reposition heater hose outlet clamp at heater core.
- Disconnect heater outlet ho...
CLICK HERE TO GET FULL ACCESS TO 2007 Ford Explorer Sport Trac RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2007 Ford Explorer Sport Trac AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2007 Ford Explorer Sport Trac XLT 4.6 V8 GAS
Always use square drive tool in hole in tensioner to move tensioner. Never pry on tensioner pulley. When releasing drive belt tensioner, never allow tensioner to snap back. Damage to tensioner or pers...
CLICK HERE TO GET FULL ACCESS TO 2007 Ford Explorer Sport Trac SERPENTINE BELT SERVICE PROCEDURES
COMPONENT LOCATION DIAGRAMS FOR 2007 Ford Explorer Sport Trac AUTOMOBILES
Component location diagrams for most 2007 Ford Explorer Sport Trac cars and light trucks sold in the U.S. from 1990+.
Body Components Diagram for 2007 Ford Explorer Sport Trac XLT 4.0 V6 GAS Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Ford Explorer Sport Trac PARTS/COMPONENTS LOCATION DIAGRAMS!
WIRING DIAGRAMS FOR 2007 Ford Explorer Sport Trac AUTOMOBILES
OEM drawn wiring diagrams for most 2007 Ford Explorer Sport Trac cars and light trucks sold in the U.S.
2007 Ford Explorer Sport Trac XLT 4.6 V8 GAS Wiring Diagram Components on diagram: |
2007 Ford Explorer Sport Trac XLT 4.0 V6 GAS Wiring Diagram Components on diagram: |
CLICK HERE TO GET FULL ACCESS TO 2007 Ford Explorer Sport Trac WIRING DIAGRAMS!
TECHNICAL SERVICE BULLETINS FOR 2007 Ford Explorer Sport Trac AUTOMOBILES
OEM TSB listings for most 2007 Ford Explorer Sport Trac cars and light trucks sold in the U.S. from 1985+.
Document: Coolant Expansion Tank Leaks - 4.0L Engine Vehicle: 2007 Ford Explorer Sport Trac XLT 4.0 V6 GAS Symptoms: |
Document: POPPING/SNAPPING NOISE - FRONT OR REAR 18 INCH WHEELS - TURNING AT SLOW SPEED BELOW 10 MPH (16 KM/H) Vehicle: 2007 Ford Explorer Sport Trac XLT 4.6 V8 GAS Symptoms: |
CLICK HERE TO GET FULL ACCESS TO 2007 Ford Explorer Sport Trac TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2007 Ford Explorer Sport Trac AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2007 Ford Explorer Sport Trac cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2007 Ford Explorer Sport Trac cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2007 Ford Explorer Sport Trac cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2007 Ford Explorer Sport Trac cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2007 Ford Explorer Sport Trac SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2007 Ford Explorer Sport Trac vehicle. |
Access the Complete guide! |