Auto Parts Search
2009 Ford F-450 Super Duty CAR/TRUCK REPAIR PROCEDURES AND DIAGRAMS - WHAT Ford REPAIR SHOPS DON'T WANT YOU TO KNOW
Learn how to repair a car or truck, install or remove parts, wire an engine, reset warning lights, replace fuel filter, fix auto body and more. Get Automotix DIY!Select Section
- Technical Service Bulletins
- Specifications
- Driveline, U-Joint & CV Axles Replacement
- Tire Pressure Monitoring System
- Starter & Alternator Replacement
- Radiator & Hose Replacement
- Serpentine Belt Service
DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES FOR 2009 Ford F-450 Super Duty AUTOMOBILES
DRIVESHAFT, Replace -> Front -> One Piece Driveshaft -> Rear -> Three Piece Driveshaft -> Two Piece Driveshaft
Vehicle: 2009 Ford F-450 Super Duty XLT 6.4 V8 DIESEL
Front
- Raise and support the vehicle.
- Index-mark front driveshaft to front axle flange and at transfer case flange.
- Remove and discard bolts and U-joint retainers.
- Remove and discard four flange bolts.
- Compress and separate front driveshaft from front axle, then separate driveshaft from transfer case. Wrap electrical tape around the bearing cups to prevent them from falling off the U-joint spider.
- Reverse procedure to install, noting the following:
- Torque flange bolts to 82 ft. lbs.
- Torque U-joint retainer bolts to 26 ft. lbs.
Rear
One Piece Driveshaft
- Raise and support vehicle.
- To maint...
CLICK HERE TO GET FULL ACCESS TO 2009 Ford F-450 Super Duty DRIVELINE, U-JOINT & CV AXLES REPLACEMENT PROCEDURES
TIRE PRESSURE MONITORING SYSTEM PROCEDURES FOR 2009 Ford F-450 Super Duty AUTOMOBILES
Component Locations
Vehicle: 2009 Ford F-450 Super Duty Lariat 6.4 V8 DIESEL
Refer to F...
CLICK HERE TO GET FULL ACCESS TO 2009 Ford F-450 Super Duty TIRE PRESSURE MONITORING SYSTEM PROCEDURES
STARTER & ALTERNATOR REPLACEMENT PROCEDURES FOR 2009 Ford F-450 Super Duty AUTOMOBILES
Alternator, Replace -> Dual Alternators -> Single Alternator
Vehicle: 2009 Ford F-450 Super Duty XL 6.4 V8 DIESEL
Single Alternator
This procedure also applies to primary alternator of the dual alternator system.
- Disconnect ground cables for dual batteries. Ground path is through the frame.
- Remove bolt and position MAP sensor aside.
- Remove ground strap bolt at bulkhead and position ground strap aside.
- Remove bolts and position power steering fluid reservoir bracket aside.
- Remove bolts and position cowl wiring harness aside.
- Remove bracket screws from charge air cooler tube bracket.
- Remove stud nuts and CAC tube bracket.
- Loosen clamps and remove CAC tube.
- Rotate accessory drive belt tensioner cloc...
CLICK HERE TO GET FULL ACCESS TO 2009 Ford F-450 Super Duty STARTER & ALTERNATOR REPLACEMENT PROCEDURES
RADIATOR & HOSE REPLACEMENT PROCEDURES FOR 2009 Ford F-450 Super Duty AUTOMOBILES
Heater Hose, Replace -> Inlet -> Outlet
Vehicle: 2009 Ford F-450 Super Duty HARLEY-DAVIDSON Edition 6.4 V8 DIESEL
Inlet
- Drain cooling system into a suitable container.
- Reposition heater core inlet hose clamp at heater tube assembly.
- Remove hose from heater tube assembly.
- Reposition heater hose inlet clamp at heater core.
- Remove heater inlet hose from heater core.
- Remove hose from vehicle.
- Reverse procedure to in...
CLICK HERE TO GET FULL ACCESS TO 2009 Ford F-450 Super Duty RADIATOR & HOSE REPLACEMENT PROCEDURES
SERPENTINE BELT SERVICE PROCEDURES FOR 2009 Ford F-450 Super Duty AUTOMOBILES
Serpentine Drive Belt, Replace
Vehicle: 2009 Ford F-450 Super Duty King Ranch 6.4 V8 DIESEL
- Drain cooling system into a suitable container.
- Remove righthand charge air cooler (CAC) tube.
- Remove cooling fan upper shroud.
- Position fan to access accessory drive belt tensioner.
- Rotate or lift belt tensi...
CLICK HERE TO GET FULL ACCESS TO 2009 Ford F-450 Super Duty SERPENTINE BELT SERVICE PROCEDURES
TECHNICAL SERVICE BULLETINS FOR 2009 Ford F-450 Super Duty AUTOMOBILES
OEM TSB listings for most 2009 Ford F-450 Super Duty cars and light trucks sold in the U.S. from 1985+.
Document: 6.4L Diesel - Cold Weather Belt Chirp Vehicle: 2009 Ford F-450 Super Duty Lariat 6.4 V8 DIESEL Symptoms: |
Document: SYNC SOFTWARE UPDATE - VARIOUS ISSUES Vehicle: 2009 Ford F-450 Super Duty Lariat 6.4 V8 DIESEL Auto Systems: |
CLICK HERE TO GET FULL ACCESS TO 2009 Ford F-450 Super Duty TECHNICAL SERVICE BULLETINS!
COMPONENT/PARTS SPECIFICATIONS FOR 2009 Ford F-450 Super Duty AUTOMOBILES
BRAKE SPECIFICATIONS: Brake drum, rotor, caliper, and related specifications for most 2009 Ford F-450 Super Duty cars and light trucks sold in the U.S. and Canada from 1970+.
- Brake caliper mounting bolt torque
- Brake drum runout, machining, & discard specs
- Minimum brake lining thickness.
- Brake rotor runout, parallelism, machining, discard, & finish specs
A/C SYSTEM SPECIFICATIONS: Air conditioning refrigerant capacity and type as well as lubricant capacity for most 2009 Ford F-450 Super Duty cars and light trucks sold in the U.S. and Canada from 1980+.
- Refrigerant capacity & type, compressor oil viscosity, total system oil capacity & compressor clutch gap
COOLING SYSTEM BLEED: Cooling system bleeder valve identification, bleeder type and bleed procedures for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1986+.
PREVENTIVE MAINTENANCE: Preventive maintenance recommendations and required services for most domestic and imported cars and light trucks sold in the U.S. and Canada from 1980+. Includes severe and routine service schedules
QUICK-LUBE and ILLUSTRATIONS: Fluid recommendations, capacities, drain plug torques, tire data, and severe service recommended preventive maintenance schedules. Information covers most 2009 Ford F-450 Super Duty cars and light trucks sold in the U.S. and Canada from 1980+. Engine and chassis service images.
- Automatic transmission/transaxles capacities, lubricant recommendations
- Differential/final drive capacities, lube recommendations, grades, & viscosities
- Final drive fill & drain plug torques
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Manual transmission/transaxle capacities, lube recommendations, grades, & viscosities
- Number of lubrication fittings & plugs
- Power steering, brake, & clutch fluid recommendations
- Engine oil capacities, API grade recommendations, SAE viscosity recommendations, drain plug torque
- Severe service maintenance & interval recommendations
- Tire sizes, wheel nut/bolt torque, pressures & rim sizes
- Transfer case capacities, lube recommendations, grades, & viscosities
TUNE-UP & DRIVEABILITY SPECIFICATIONS: Most tune-up specifications for most 2009 Ford F-450 Super Duty cars and light trucks sold in the U.S. and Canada from 1980+
- Airflow sensor electrical specifications
- Tensioning specifications for systems with automatic tensioners
- Barometric pressure sensor specs
- Battery group number and cranking performance
- Crankshaft & camshaft position sensor resistance
- Engine compression pressures
- Coolant temperature sensor specs
- Computer advance.
- Diesel fuel temperature sensor resistance.
- Distributor advance specifications
- Ignition pickup coil resistance
- Exhaust gas recirculation temperature sensor resistance
- Engine fastener torque values
- Firing order diagrams
- Fuel system pressures
- Generator (alternator) specs
- Intake air temperature sensor specs
- Ignition coil specifications
- Fuel injector resistance
- Engine idle speeds
- Knock sensor resistance
- Manifold absolute pressure sensor specs
- Mixture control solenoid resistance
- Voltage regulator specs
- Spark plug applications & gaps
- Starter motor electrical specs.
- Tensioning specifications for systems without automatic tensioners
- Throttle body temperature sensor resistance
- Ignition timing in degrees at rpm
- Transmission oil temperature sensor resistance
- Throttle position sensor specs
- Vacuum sensor valve specs
CLICK HERE TO GET FULL ACCESS TO 2009 Ford F-450 Super Duty SPECIFICATIONS DATA!
Shop online for auto body parts, engines, wheels, lights...
More parts |
Get the Complete Technical Service Bulletins! |
Access diagrams and repair information such as wiring diagrams, diagnosis and repair charts, manufacturer service bulletins, and OEM Part numbers of your 2009 Ford F-450 Super Duty vehicle. |
Access the Complete guide! |